honeywell 5500e generator manual

HoneywellGenerators 13,780 views. •ALWAYS disconnect negative (-) battery lead first. •NEVER touch hot surfaces and avoid hot gases. For initial start-up, follow instructions on oil container provided with generator. Great Choice Generators and Compare Price to Buy online in Us. 5.Attach a rubber stopper to bottom of each support leg using a 25 mm full-thread hex bolt and 13 mm flange serrated nut; tighten until securely seated. The Smart Start instruction card is NOT intended to replace information provided in this Owner’s Manual. Carefully return recoil starter handle to its original position. Honeywell Portable Generators - How to Start Your Electric Start Portable Generator - Duration: 3:57. You check prices before buying Honeywell 5500E-6037 5500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start at … yes, we have”+Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start” here. There may be Federal or State Occupational Safety and Health Administration (OSHA) regulations, local codes, or ordinances that apply to the intended use of generator. 100900A HONEYWELL GENERATORS PART 100900A Owners Manual 5500/5500E 100901A HONEYWELL GENERATORS PART 100901A Owners Manual (4000) 100921A HONEYWELL GENERATORS PART 100921A Fuel Tank Price includes additional $12.00 freight charge •Before attempting to power an appliance, be sure generator has been properly grounded, and that appliance and power cord are in good working order. May have reduced the price now. •If generator is used at a construction site, there may be additional regulations which must be observed. Fuel and its vapors are extremely flammable and explosive under certain conditions. If you always operate the engine at altitudes higher than 5000 feet (1500 meters) above sea level, have an authorized generator dealer perform this carburetor modification. Before performing maintenance, disconnect spark plug cap from spark plug.Also disconnect both starting battery cables. Required fields are marked *, This work is licensed under a Creative Commons Attribution-Noncommercial-Share Alike 3.0 United States License. •Holding engine control switch for more than 5 seconds can damage starter motor. Welcome to ManualMachine. All safety messages are introduced by a signal word indicating the hazard level. 2.Remove all contents, except generator unit. •Power 240V appliances using appropriate (L14-30) power cord (not included). See page 12. 1.Hold handle bracket over pre-drilled holes on frame as shown in Figure 9. 2.Be sure generator is set on flat, level surface. FIGURE 16: Fuel Valve Lever — ON/OFF position. Turn generator OFF and allow to cool before filling with fuel. IN-STORE INTERNET PRINT RADIO/TV STORE CIRCULAR WORD OF MOUTH 3 ­ DEMOGRAPHIC INFORMATION GENDER: MALE FEMALE MARITAL STATUS: MARRIED SINGLE DATE OF BIRTH: HOUSEHOLD INCOME LESS, Your email address will not be published. NUMBER OF CHILDREN UNDER 18 LIVING IN YOUR HOUSEHOLD: TYPES OF CREDIT CARDS HELD BY HOUSEHOLD MEMBERS: _________________________________________. Handle should stick straight out after tightening bolts and nuts. •NEVER enclose the generator in any structure. 1.Stop generator if engine is running. 120V 20 Amp Duplex outlets to connect 120V appliances to generator for power. Carefully return recoil starter handle to original position. PRIMARY METHOD OF PURCHASING HOUSEHOLD ITEMS: INCLUDING YOUR SELF, HOW MANY PEOPLE LIVE IN YOUR HOUSEHOLD? Performance will decrease and fuel consumption will increase. •NEVER overload: Circuit breakers will stop flow of electricity between generator and appliance if generator is overloaded. The Honeywell Trademark is used under license from, Honeywell International Inc. makes no representations or, To register your product, please complete the information below and mail to the mailing address at the end of form, or register online at www.honeywellgenerators.com, CHECK HERE TO RECEIVE PRODUCT REMINDERS AND OFFERS VIA EMAIL, CHECK HERE TO RECEIVE INFORMATION FROM OTHER COMPANIES VIA EMAIL, UNDERSTANDING YOUR EMAIL ADDRESS MAY BE SHARED OR COMBINED WITH INFORMATION FROM OTHER SOURCES. Delivers volts to spark plug. Failure to closely follow these instructions can result in circumstances leading to death, serious injury, and property damage. When using recoil starter, pull cord firmly and slowly until you feel resistance and then pull rapidly to avoid kickback. Buy Honeywell 5500E (6037)Generator Parts now. •Connect a transfer switch to building’s main electrical system for backup power (see page 12). Honeywell 5500E 6037 Portable Generator Electric Best Deal Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start Special Offer! Carefully return recoil starter handle to original position. Newegg shopping upgraded ™ If engine must be run, be sure area is well ventilated. HOW DID YOU BECOME AWARE OF THIS PRODUCT? Spilled fuel or fuel vapor may ignite. Generator produces powerful voltage that can cause death or great physical harm. Honeywell HW5500 - 5500 Portable Generator Pdf User Manuals. Indicates a situation which, if not avoided, may result in damage to generator components. yes, we have”*Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start” here. Find replacement batteries for many name brand battery generators at Batteries Plus Bulbs. Be sure that power rating of appliance does not exceed that of generator. •NEVER operate generator in rain or snow, or when the generator is set on wet surface. Si tiene preguntas acerca de los productos o requiere de asistencia, visite www.honeywellgenerators.com o llame gratis al 1-888-494-3571. Samples of these labels are provided below. •To return handles to horizontal position, pull up on handle. 9.Allow oil to completely drain into oil pan or container. Plenty of Wattage to Run a Full Range of Appliances. ANYONE using the generator must read, understand, and follow all safety and operation instructions provided in the product manual. Hot engine oil can cause severe burns. •Be careful not to spill fuel when refueling. * These kits include the components necessary to convert the generator that you have selected. post on battery; fasten with bolt and nut. Before using generator, consult a qualified electrician, electrical inspector, or local agency having jurisdiction for local codes or ordinances that apply to the intended use of generator. 2.Allow generator to run for 2-3 minutes. NEVER OVERFILL. Check labels inside or on the back of appliance, refer to appliance operating manuals, or contact appliance manufacturer. You will not be able to start engine until you add required amount of engine oil. Electrical current from generator to feedback into utility lines. For your safety, and the safety of others, be sure to read this manual thoroughly before operating the generator. •NEVER overfill fuel tank (no fuel should be in filler neck). View and Download Honeywell HW5500 - 5500 Portable Generator owner's manual online. To avoid electric arcing, which can result in electric shock, follow these instructions exactly. Engineers are always happy to help. •Immediately after handling engine oil, thoroughly wash hands and any areas of skin exposed to engine oil, with soap and water. •In some areas, generators are required to be registered with local utility companies. Consult a licensed electrician or utility company if you will be using your generator for backup power. See “Adding Fuel” on page 22. We guarantee you will deals Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator Review prices here.… Using a generator indoors CAN KILL YOU IN MINUTES. •Use suitable extension cords: If using an extension cord to connect appliance to generator, use only ULlisted, three-prong extension cords. Disconnect appliance and determine whether problem is appliance, or if rated load capacity of generator has been exceeded. Check it out Now and You will get Special Promotion In Stock & Saver and Faster Shipping in USA.Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric … The Honeywell Model # 5500E-6037 portable gas powered generator with a steel frame protecting the engine from damage, the Honeywell 5500 Watt portable generator is ideal for home emergency, events, power tools and more. Congratulations on owning a Honeywell portable generator This manual contains important instructions for operating this generator. •Shut off engine before performing any maintenance. What’s in the Box. Since there are many variations in the circumstances surrounding the installation, operation, and maintenance of this generator unit, we cannot possibly anticipate or provide advice or safety messages to cover every situation. 10.Using clean cloth, wipe around oil fill and drain plug areas to clean any dirt and debris. If you will be using generator for backup power, generator must be connected to building’s electrical system through a transfer switch installed by a licensed electrician. NEVER tamper with governed speed. If generator is tilted or overturned, fuel spillage may result. NEVER allow open flames, lit cigarettes, sparks, or. PLEASE RETURN THIS FORM TO THE FOLLOWING ADDRESS: PLEASE MAIL THIS FORM IN A SEALED ENVELOPE. •Keep generator at least 3 feet (1 meter) away from buildings and other equipment during operation. NOTE: Illustration below shows battery, which is available only with HW5500E models. If appliance begins to operate abnormally, becomes sluggish, or stops suddenly, turn it OFF immediately. Plus, this generator's sturdy, 5.8-gallon fuel tank ensures a full 9.1 hours of operation at a 50-percent load, letting you relax for hours of use. View online or download Honeywell HW5500 - 5500 Portable Generator Owner's Manual, Specification Sheet 12.Pour new (unused) engine oil into oil fill hole. TABLE 1. for +Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start. NEVER overfill the fuel tank (there should be no fuel in the filler neck). Reinstall sealing washer and drain plug bolt. If using a receptacle tester, it will not show same ground circuit condition as for a home receptacle. •Pay attention to appliance operation: If appliance begins to operate abnormally, becomes sluggish, or stops suddenly, turn it OFF immediately. Need a reliable, high-performance Honeywell HW5500E Generator Batteries? Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury to the operator or to bystanders. See Prices; Showing Products 1 - 38 of 38 Problems & Solutions. High altitude performance can be improved by installing a smaller diameter main fuel jet in the carburetor and then readjusting the pilot screw. •NEVER smoke or allow flames or sparks near generator or where gasoline is stored. Drain engine oil and fuel, if necessary. NEVER use generator inside homes, garages, crawl spaces, sheds, or similar enclosed spaces. NEVER operate generator in rain or snow, or when the generator is set on wet surface. This is the best place to buy Generators and Portable Power available On Sale.… You can buy *Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start Shops & Purchase Online. Do not run power cords under carpet, rugs, or other materials where heat might build up or cord damage may go unnoticed. Install other bracket (included in hardware bag) to frame. WHO DECIDED TO PURCHASE THIS PRODUCT? Engineers are always happy to help. Need advice? USA Canada UK EU Aus NZ Spilled fuel or fuel vapor may ignite. See “Adding Fuel” on page 22. Please consult a qualified electrician, electrical inspector, or the local agency having jurisdiction. yes, we have “!Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start” for sale. The generator pictures and information displayed on our conversion kit pages are here solely for identification purposes only. Be careful not to spill fuel when refueling. Generator exhaust contains carbon monoxide. Be sure to thoroughly read and understand all information provided in Owner’s Manual before operating generator. Allow to completely cool. Power rating information can usually be found on an appliance’s product label, or stamped inside or on back of appliance. Honeywell 5500 Portable Generator, Midwest Power Inlet Box, Manual Transfer SwitchWhole house generator Needs new battery but starts right upNot sure what all is needed to hook this up to run the whole house but I think this is all but not 100 sureAlmost new condition other items brand newLocation is near TriCounty soccer on Freedom rd 850 or make offerDo not bother low balling I will Owner Manual: MANUAL 5.5-7.5KW HNYWL PORT 0J3808: EN: Emissions Warranty Statement: WARRANTY STATEMENT EMSN E P3 0J3335: EN: Unit Warranty Statement: WARRANTY HONEYWELL 3YR/1YR 0J3304: EN: Parts Manual / EV (Engine) PARTS MNL 389CC GAS ENG(G19) HOW DID YOU BECOME AWARE OF THIS PRODUCT? If you notice engine cranking speed drop after a period of time, it may be an indication that battery should be recharged. For your safety, and the safety of others, be sure to read this manual thoroughly before operating the generator. Be sure generator is set on flat, level surface. The future is what we make it. Transfer switch is either a manual switch, an automatic switch or a combination of manual and automatic. Im a 70 year old and as I say older than Moses tablets and I was having trouble finding part … Find many great new & used options and get the best deals for Honeywell 5500E Portable Electric Start Generator at the best online prices at eBay! Other viscosities shown in chart may be used when average temperature in your area is within indicated range. 3.Press engine control switch to STOP position. If you operate generator under severe conditions, such as sustained high-load or high-temperature, or use it in unusually wet or dusty conditions, consult your servicing dealer for recommendations applicable to your individual needs and use. You can buy !Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start here. Honeywell Portable Generator Hw5500 Users Manual HW5500/5500E Owner's Honeywell Portable Generator HW5500E HW5500 HW5500 to the manual 082bb941-df49-4dd0-8479-19d4ab79ee83 If any fuel is spilled, be sure the area is dry before starting the engine. 5.Pull out to read current oil level indicated on dipstick end. Generator must be empty of engine oil and fuel. 6.Reinstall oil fill cap and fully tighten. Controls flow of fuel from fuel tank to carburetor. •Keep hands and fingers clear from hinges when collapsing generator handles. Plus, this generator's sturdy, 5.8-gallon fuel tank ensures a full 9 hours of operation at a 50-percent load, letting you relax for hours of use. Slide and push wheel onto axle until it fits snug against washer. Explore how the features and benefits of a 5,500 watt Honeywell portable generator can supply reliable power whether you’re home or on the go. Crankcase pressure can cause hot engine oil to spray out of engine fill hole. Immediately after handling engine oil, thoroughly wash hands and any areas of skin exposed to engine oil, with soap and water. Buy Honeywell 6037-5500E 5500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start with fast shipping and top-rated customer service. Please use spaces provided below to write down important information about your generator. Congratulations on owning a Honeywell portable generator. it is easy to see way more the item ratings at the same time as fees. Garden product manuals and free pdf instructions. 6037 5500E Watt Portable, 49/CSA; Electric Start Product Features Honeywell 5500E Watt Portable Generator, CSA Back About this item Disclaimer: While we aim to provide accurate product information, it is provided by manufacturers, suppliers and others, and has not been verified by us. Protect what matters most with the power of Honeywell Generators. 8.Slowly unscrew and remove oil fill cap. Place 5/16" washer in center of each rubber stopper. Using a socket wrench with 12 mm socket, loosen drain plug bolt; remove drain bolt and sealing washer. Check fuel gauge located on the top of generator near fuel tank and refill tank if fuel level is low. Before starting generator, complete the following preparation tasks: Be sure generator is placed outdoors in a well ventilated area. Generator must be grounded to prevent electrical shock from faulty appliances. Your generator is packaged with several labels which provide important safety and maintenance information. Always follow inspection and maintenance recommendations and schedules in this owner's manual. SAE 10W-30 is recommended for general temperature use. See “Using Generator for Backup Power” on page 12. See Table 1 for a listing of average appliance wattage requirements. Frequent or prolonged contact with engine oil may cause skin cancer. NEVER use wheel kit for any other purpose. Indicates a potentially hazardous situation which, if not avoided, may result in moderate or minor injury to the operator or to bystanders. Socket Wrench with 10 mm Socket* * Not included. 6.Using a socket wrench with 12 mm socket, loosen drain plug bolt; remove drain bolt and sealing washer. Oxygenated fuels can damage paint and plastic. Need a reliable, high-performance Honeywell HW5500E Generator Batteries? Generator must be grounded to prevent electrical shock from faulty appliances. View and Download Honeywell HW5500E instruction manual online. Prevents sparks and other combustible materials from escaping generator. It is very important to maintain proper level of engine oil to keep engine in good running condition. Refill engine oil if oil level is too low. You may be asked to provide this information should you require product service or support. Date of Purchase: Store/Dealer Purchased From: Generator Model Number: Generator Serial Number: Northshore Power Systems, LLC 4425 N. Port Washington Rd., Suite 105 Milwaukee, WI 53212-1082 USA TEL 1-888-494-3571 honeywellgenerators.com 2008 Northshore Power Systems LLC The Honeywell Trademark is used under license from Honeywell International Inc. Honeywell International Inc. makes … Please check your inbox, and if you can’t find it, … Oil level should be at “H” or somewhere between the “L” and “H”. Battery electrolyte fluid is comprised of sulfuric acid, which can be very dangerous and cause severe burns. Once properly installed, the handles can be collapsed, if desired. Using clean cloth, wipe around oil fill and drain plug areas to clean any dirt and debris. CHECK HERE IF YOU DO NOT WISH TO BE CONTACTED ABOUT SPECIAL OFFERS. Use approved transfer equipment to isolate generator from electric utility. See promotion prices visit in store. The values provided in following table are estimates only. Exposed terminals, even on disconnected batteries, can cause electric shock. NEVER touch hot surfaces. Mark was so helpful. Composting is an superb way of manufacturing selfmade fertilizer that presents a layer of nutrient abundant resources … This will be indicated by a “tripped” breaker. Best Honeywell Manual HW5000 HW5000E 6036 6037 6151 5500 6875W Generator Carburetor Cheap. Refer to Operation section (page 15) for instructions on operating generator. The Honeywell Model # 5500-6036 portable gas powered generator with a steel frame protecting the engine from damage, the Honeywell 5500 Watt portable generator is ideal for home emergency, events, power tools and more. ANYONE using or servicing generator must read, understand, and follow all safety and operation instructions provided in product manual. Honeywell Portable Generator User Manual. Designed to provide a reliable source of portable power ideal for a variety of uses, the Honeywell 5500E-6037 gas-powered generator is ideal … Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start is the best goods brought out the foregoing week . Two brackets are needed to install wheel axle. WARRANTIES ................................................................................................................... NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY .............................................. NORTHSHORE POWER SYSTEMS LIMITED WARRANTY ...................................................................... INDEX ................................................................................................................................. HW5500/5500E MAINTENANCE PARTS ......................................................................... HW5500/5500E Portable Generator Owner’s Manual. Loosen and remove nuts on retaining plate; slide retaining plate off support rods. If metal comes into contact with battery terminals, electric shock and serious burns can result. Honeywell HW5500 and HW5500E Generator Parts. User Manuals, Guides and Specifications for your Honeywell HW5500 - 5500 Portable Generator Portable Generator. Identification information specific to your generator (model number and serial number) can be found on generator’s nameplate. 1B. If metal comes into contact with battery terminals, electric shock and serious burns can result. FIGURE 12: Electric Starter Battery—Remove Retaining Plate. Identification information specific to your generator (model number and serial number) can be found on generator’s nameplate. is at “H” or somewhere between the “L” and “H”, reinstall oil fill cap and fully tighten. Perform service and inspection at intervals shown in Generator Maintenance Schedule (Table 2). Date of Purchase: Store/Dealer Purchased From: Generator Model Number: Generator Serial Number: Northshore Power Systems, LLC 4425 N. Port Washington Rd., Suite 105 Milwaukee, WI 53212-1082 USA TEL 1-888-494-3571 honeywellgenerators.com 2008 Northshore Power Systems LLC The Honeywell Trademark is used under license from Honeywell International Inc. Honeywell International Inc. makes … Stop generator if engine is running. Improper connections to a building's electrical system can be deadly. You Can purchase Honeywell 5500E-6037 5500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start at online store. The leader in Portable Generator Parts. Starting appliances that have motors requires more power. You can buy +Honeywell 5500E-6037 5,500 Watt 389cc OHV Portable Gas Powered Generator with Electric Start Shops & Purchase… Turn OFF any connected appliances and unplug any connected power cords. You must add fuel before using the generator for the first time. Hands and fingers can be pinched from collapsible handles. Be sure to use engine oils specified under “Engine Oil Recommendations.”. The leak starts after the gasoline valve is turned on and before the engine is started. You have been successfully registered. Place generator on firm, level surface and avoid loose sand or snow. Turn generator OFF and allow to cool before filling with fuel. † Clean more often when using generator in dusty areas. Do not fill above the shoulder of fuel strainer. During a power outage, transfer switch isolates emergency circuits from utility line, allowing for efficient operation of generator without backfeeding onto utility. USA Canada UK EU Aus NZ Check out Expert's recommended alternatives for another top portable generators gas generator. These had been delivered at a value tag far a lot less than I could get locally. Before starting generator, be sure to thoroughly read all information provided in this Owner’s Manual. Press engine control switch to RUN position. •NEVER smoke or allow flames or sparks near the generator or where gasoline is stored. •NEVER allow open flames, lit cigarettes, sparks, or spark-producing equipment near the battery. Use fresh gasoline with a pump octane rating of 87 or higher.
honeywell 5500e generator manual 2021